Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics

From The Encyclopedia of Earth
Jump to: navigation, search
Microbiology (main)


Camel-icon.png

This article appeared first in mBio, an open-access journal of the American Society for Microbiology operating under the terms of the Creative Commons Attribution-Noncommercial-Share Alike 3.0 Unported License.

The article is a verbatim version of the original and is not available for edits or additions by Encyclopedia of Earth editors or authors. Companion articles on the same topic that are editable may exist within the Encyclopedia of Earth.

Microbial Electrosynthesis: Feeding Microbes Electricity
To Convert Carbon Dioxide and Water to Multicarbon
Extracellular Organic Compounds

Abstract

The possibility of providing the acetogenic microorganism Sporomusa ovata with electrons delivered directly to the cells with a graphite electrode for the reduction of carbon dioxide to organic compounds was investigated. Biofilms of S.ovata growing on graphite cathode surfaces consumed electrons with the reduction of carbon dioxide to acetate and small amounts of 2-oxobutyrate. Electrons appearing in these products accounted for over 85% of the electrons consumed. These results demonstrate that microbial production of multicarbon organic compounds from carbon dioxide and water with electricity as the energy source is feasible.

Importance Reducing carbon dioxide to multicarbon organic chemicals and fuels with electricity has been identified as an attractive strategy to convert solar energy that is harvested intermittently with photovoltaic technology and store it as covalent chemical bonds. The organic compounds produced can then be distributed via existing infrastructure. Nonbiological electrochemical reduction of carbon dioxide has proven problematic. The results presented here suggest that microbiological catalysts may be a robust alternative, and when coupled with photovoltaics, current-driven microbial carbon dioxide reduction represents a new form of photosynthesis that might convert solar energy to organic products more effectively than traditional biomass-based strategies.

Introduction

The intermittent nature of renewable sources of energy, most notably solar and wind, is leading to a search for strategies to capture the electrical energy produced from these sources in covalent chemical bonds, producing compounds that can readily be stored and consumed on demand, preferably within the existing infrastructure (1 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). One particularly attractive option is to reduce carbon dioxide to produce multicarbon organic compounds that are precursors for desirable organic chemicals or liquid transportation fuels (2 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). Basic requirements for a practical system to fix carbon dioxide in this manner include (i) the ability to use electrons derived from water as an abundant, inexpensive source of reductant (1 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 2 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)); and (ii) inexpensive, durable catalysts (3 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)).

Reaction thermodynamics suggests that it should be readily feasible to electrochemically reduce carbon dioxide to a diversity of organic compounds, and this process has been studied for over a hundred years (4, 5 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). However, in practice, abiotic electrochemical reduction of carbon dioxide has not proven practical in large part due to (i) poor long-term stability of the cathodes, (ii) nonspecificity of products produced, (iii) sluggishness of carbon dioxide reduction, (iv) competition with hydrogen production, and (v) cathode expense (3 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). Incorporating enzyme catalysts on electrodes may promote more specific product formation from electrochemical reduction of carbon dioxide and lower the energy required for reduction (3 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), but experiments on enzymatic reduction have typically lasted only a matter of hours, reflecting the fact that enzymes adsorbed to electrodes do not have long-term stability.

Acetogenic bacteria can reduce carbon dioxide to acetate and other multicarbon extracellular products with hydrogen as the electron donor (6 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 7 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). However, supplying acetogens with hydrogen that is produced electrochemically is unlikely to be practical because it would require expensive catalysts and/or substantial energy inputs (8 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). An alternative might be to directly feed acetogens electrons with electrodes. Geobacter and Anaeromyxobacter species have previously been shown to accept electrons from graphite electrodes for the reduction of fumarate to succinate (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), the reduction of nitrate to nitrite (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), U(VI) reduction (10 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), or reductive dechlorination (11 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 12 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). It has also been suggested that it may be possible to directly supply methanogenic microorganisms electrons at electrode surfaces for carbon dioxide reduction to methane (13 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), but this has been difficult to verify because there can be significant electrochemical hydrogen production at the low electrode potentials required for active methanogenesis (14 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)).

Culturing in H cells.

We evaluated the possibility of feeding an acetogen electrons from an electrode with Sporomusa ovata (15) (Deutsche Sammlung Mikroorganismen und Zellkulturen [DSMZ] culture 2662). Cells were grown in the cathode chambers of “H cells” (Fig.1a), which have previously been used to evaluate other forms of electrode-driven anaerobic respiration (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)12 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). The cathode and anode were comprised of unpolished graphite sticks. The anode and cathode chambers, each containing 200ml of medium, were separated with a Nafion cation-exchange membrane. A potentiostat maintained a potential difference between the anode and cathode. Electrons extracted from water at the anode were delivered to the cathode at −400mV (versus standard hydrogen electrode), a potential well above the −600mV necessary to produce even low levels of hydrogen with unpolished graphite (8 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). The lack of hydrogen production was verified by directly measuring hydrogen concentrations with a reduction gas analyzer as previously described (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). In most instances, the electrical current was obtained from a standard electrical outlet, but a solar-powered potentiostat (Fig.1a), comprised of a solar panel and voltage control unit built with standard electrical components, could also support the system.

(a) H-cell device for supplying cathode biofilms of S.ovata electrons derived from water. The solar-powered option is illustrated. 8 e, 8 electrons. (b) Electron consumption and product formation by a representative S.ovata biofilm over time. The data shown were obtained with a system connected to a standard electric current. The mean standard errors of the organic acid and current measurements were 2% and 13%, respectively.


An inoculum of S.ovata was grown with hydrogen as the electron donor (H2-CO2 [80:20]) in the DSMZ-recommended growth medium (DSMZ 311) with betaine, Casitone, and resazurin omitted. The hydrogen-grown cells were introduced into the cathode chamber in the same medium but with the yeast extract and the cysteine and sulfide reductants omitted. This bicarbonate-based medium contained no organic compounds other than a vitamin mixture, and carbon dioxide was the sole electron acceptor. The culture was initially bubbled with a hydrogen-containing gas mixture (N2-CO2-H2 [80:13:7]) as an additional electron donor to accelerate the growth of a biofilm on the cathode surface. Acetate was measured with high-performance liquid chromatography (HPLC) (16 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). Once acetate reached 10mM, 50% of the medium was replaced with fresh medium. This process was repeated three times. This periodic removal of planktonic cells promoted biofilm growth on the cathode. The gas phase was then switched to N2-CO2 (80:20). Once the consumption of current was observed (within 24h), the system was switched to flowthrough mode in which fresh medium maintained under N2-CO2 was continuously introduced (0.1ml/min; dilution rate of 0.03h−1) as previously described (16 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 17 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). Hydrogen partial pressures in the headspace remained less than 10ppm throughout the study, ca. 2 orders of magnitude below the minimum threshold for acetate production from hydrogen by acetogens (18 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)).

Systems with S.ovata steadily consumed current with the production of acetate and small amounts of 2-oxobutyrate (Fig.1b). Uninoculated controls did not consume current or produce organic acids. If the current supply to the S.ovata biofilm was interrupted, acetate and 2-oxobutyrate production stopped.

Although it was not possible to measure carbon dioxide consumption due to the high concentrations of bicarbonate in the medium, it was possible to calculate an electron balance. Electrons appearing in acetate accounted for a high proportion of the electrons that the cultures consumed (Fig.1b). In three replicate cultures, the electron recovery in acetate and 2-oxobutyrate was 86% ± 21% of the electrons transferred at the cathodes. These results demonstrated that S.ovata could accept electrons from graphite electrodes with the reduction of carbon dioxide and that most of the electrons transferred from the electrodes to the cells were diverted toward extracellular products, rather than biomass formation. The S.ovata cathode biofilms were robust and have been run for periods of more than 3months without losing their capacity for current consumption and acetate production.

The long-term viability of S.ovata biofilms was further evident from confocal scanning laser microscopy of a biofilm that had been fixing carbon dioxide for 3months. The cells in biofilms treated with LIVE/DEAD BacLight viability stain, as previously described (16 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 17 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), stained green, suggesting that they were healthy and metabolically active (Fig.2a). The biofilms were relatively thin, similar to the biofilms previously described for other microorganisms growing on cathodes (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 11 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 12 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). This was further confirmed with scanning electron micrographs of the cathode surface (Fig.2b), prepared as previously described (19 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). The cells appeared to be intimately associated with the graphite surface, as would be expected for direct electrode-to-cell electron transfer (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 11 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 12 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). There was no visible turbidity in the cathode chamber, consistent with previous studies on direct electrode-driven respiration (9 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)12 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)) and further suggesting that biofilm cells were primarily responsible for current consumption and carbon dioxide reduction.

FIG 2

FIG 2

Cathode biofilms of S.ovata. (a) Confocal scanning laser microscopic images (top down and side views) of cathode surface. Cells were stained with LIVE/DEAD BacLight viability stain. (b) Scanning electron microscopic image of cathode surface with cells highlighted in yellow.


Implications.

These results demonstrate that S.ovata is capable of using electrons derived from an electrode as the sole electron donor for the reduction of carbon dioxide to acetate. The high coulumbic efficiencies of acetate production (electrons appearing in acetate/electrons consumed as current) are consistent with the following reaction: 2CO2 + 2 H2O → CH3COOH + 2O2.

This conversion of carbon dioxide and water to an organic compound and oxygen is the same net reaction as oxygenic photosynthesis. We propose the term microbial electrosynthesis for the reduction of carbon dioxide to multicarbon compounds with electrons donated from an electrode as the electron donor. Microbial electrosynthesis differs significantly from photosynthesis in that carbon and electron flow is directed primarily to the formation of extracellular products, rather than biomass. Biomass typically requires extensive additional processing for chemical or fuel production. When coupled to a photovoltaic system, microbial electrosynthesis offers a new photosynthetic technology for the production of organic products with the added advantage that photovoltaic technology is orders of magnitude more effective in capturing solar energy than photosynthesis is (20).

Although acetate has economic value (6 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), a more important consideration is that acetate is formed from acetyl coenzyme A (acetyl-CoA) (6 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 7 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)), which is the central intermediate for the genetically engineered production of a wide range of chemical commodities as well as potential liquid transportation fuels (21 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics), 22 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). The fact that small amounts of 2-oxobutyrate were produced, in addition to acetate, demonstrates that even without any engineering, some carbon and electron flow was diverted away from acetate production. The acetogen Clostridium ljungdahlii has recently been genetically engineered to produce the gasoline substitute butanol from acetyl-CoA (23 (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics)). Attempts to genetically engineer S.ovata and other acetogens to produce products other than acetate via microbial electrosynthesis are under way.

Acknowledgments

This research was supported by the Office of Science (BER), U.S Department of Energy, Cooperative Agreement DE-FC02-02ER63446.

We thank Daniel Drell, Department of Energy, for thought-provoking discussions that led to the development of this project.

Footnotes

  • Accepted 5 May 2010
  • Published 25 May 2010
  • Copyright © 2010 Nevin et al.

This is an open-access article distributed under the terms of the Creative Commons Attribution-Noncommercial-Share Alike 3.0 Unported License, which permits unrestricted noncommercial use, distribution, and reproduction in any medium, provided the original author and source are credited.

References

1. N. S. Lewis and D. G. Nocera. 2006. Powering the planet: chemical challenges in solar energy utilization. Proc. Natl. Acad. Sci. U. S. A. 103:1572915735.

2. G. Centi and S. Perathoner. 2009. Opportunities and prospects in the chemical recycling of carbon dioxide to fuels. Catal. Today 148:191205.

3. M. Aresta E. B. Cole and A. B. Bocarsly. 2010. Photochemical, electrochemical, and photochemical reduction of carbon dioxide, p. 291316. In M. Aresta , Carbon dioxide as chemical feedstock. Wiley-VCH Verlag GmbH & Co., Weinheim, Germany.

4. M. Gattrell, N. Gupta, and A. Co. 2006. A review of the aqueous electrochemical reduction of CO2 to hydrocarbons at copper. J. Electroanal. Chem. 594:119.

5. C. Olomon and H. Li. 2008. Electrochemical processing of carbon dioxide. ChemSusChem 1:385391.

6. H. L. Drake, A. S. Gössner, and S. L. Daniel. 2008. Old acetogens, new light. Ann. N. Y. Acad. Sci. 1125:100128.

7. V. Muller. 2003. Energy conservation in acetogenic bacteria. Appl. Environ. Microbiol. 69:63456353.
9. K. B. Gregory, D. R. Bond, and D. R. Lovley. 2004. Graphite electrodes as electron donors for anaerobic respiration. Environ. Microbiol. 6:596604.

10. K. B. Gregory and D. R. Lovley. 2005. Remediation and recovery of uranium from contaminated subsurface environments with electrodes. Environ. Sci. Technol. 39:89438947.

11. S. M. Strycharz, S. M. Gannon, A. R. Boles, K. P. Nevin, A. E. Franks, and D. R. Lovley. 2010. Anaeromyxobacter dehalogenans interacts with a poised graphite electrode for reductive dechlorination of 2-chlorophenol. Environ. Microbiol. Rep. 2:289294.

12. S. M. Strycharz, T. L. Woodward, J. P. Johnson, K. P. Nevin, R. A. Sanford, F. E. Loeffler, and D. R. Lovley. 2008. Graphite electrode as a sole electron donor for reductive dechlorination of tetrachlorethene by Geobacter lovleyi. Appl. Environ. Microbiol. 74:5943–5947.

13. S. Cheng, D. Xing, D. F. Call, and B. E. Logan. 2009. Direct biological conversion of electrical current into methane by electromethanogenesis. Environ. Sci. Technol. 43:39533958.

14. M. Villano, F. Aulenta, C. Ciucci, T. Ferri, A. Giuliano, and M. Majone. 2010. Bioelectrochemical reduction of CO2 to CH4 via direct and indirect extracellular electron transfer by a hydrogenophilic methanogenic culture. Bioresource Technol. 101:30853090.

15. B. Moller, R. Obmer, B. H. Howard, G. Gottschalk, and H. Hippe. 1984. Sporomusa, a new genus of gram-negative anaerobic bacteria including Sporomusa sphaeroides spec. nov. and Sporomusa ovata spec. nov. Arch. Microbiol. 139:388–396.

16. K. P. Nevin, H. Richter, S. F. Covalla, J. P. Johnson, T. L. Woodard, H. Jia, M. Zhang, and D. R. Lovley. 2008. Power output and columbic efficiencies from biofilms of Geobacter sulfurreducens comparable to mixed community microbial fuel cells. Environ. Microbiol. 10:2505–2514.

17. 1. G. Reguera, K. P. Nevin, J. S. Nicoll, S. F. Covalla, T. L. Woodard, and 6. D. R. Lovley. 2006. Biofilm and nanowire production leads to increased current in Geobacter sulfurreducens fuel cells. Appl. Environ. Microbiol. 72:7345–7348.


18. R. Cord-Ruwisch, H. Seitz, and R. Conrad. 1988. The capacity of hydrogenotrophic anaerobic bacteria to compete for traces of hydrogen depends on the redox potential of the terminal electron acceptor. Arch. Microbiol. 149:350–357.


19. J. C. Araujo, F. C. Téran, R. A. Oliveira, E. A. A. Nour, A. P. Montenegro, J. R. Campos, and R. F. Vazoller. 2003. Comparison of hexmethyldisilazane and critical point drying treatments for SEM analysis of anaerobic biofilms and granular sludge. J. Electron Microsc. 52:429–433.


20. JASON, Mitre Corporation. 2006. Engineering microorganisms for energy production. Department of Energy Report JSR-05-300. JASON, Mitre Corporation, McLean, VA.


21. J. L. Fortman, S. Chhabra, A. Mukhopadhyay, H. Chou, T. S. Lee, E. Steen, and J. D. Keasling. 2008. Biofuel alternatives to ethanol: pumping the microbial well. Trends Biotechnol. 26:375–381.


22. Y. Yan and J. C. Liao. 2009. Engineering metabolic systems for the production of advanced fuels. J. Ind. Microbiol. Biotechnol. 36:471–479.


23. M. Kopke. 2009. Genetische Veranderung von Clostridium ljungdahlii zur Produktion von 1-butanol aus Synthesegas. Ph.D. Dissertation. Ulm University, Hamburg, Germany.

Editor's Notes

  • Authors: Kelly P. Nevin, Trevor L. Woodard, Ashley E. Franks, Zarath M. Summers, and Derek R. Lovley of the Department of Microbiology, University of Massachusetts, Amherst, Massachusetts, USA. Address correspondence to Derek R. Lovley, dlovley@microbio.umass.edu (Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics) dlovley@microbio.umass.edu
  • mBio Editor Rita R. Colwell, University of Maryland.

Citation

(2012). Microbial Electrosynthesis: Carbon Dioxide and Water to Extracellular Organics. Retrieved from http://editors.eol.org/eoearth/wiki/Microbial_Electrosynthesis:_Carbon_Dioxide_and_Water_to_Extracellular_Organics